Assessment of the usefulness and feasibility of implementing the spaghetti diagram, Ishikawa diagram, and the HFMEA analysis in a hospital emergency department – a pilot study
DOI:
https://doi.org/10.12923/pielxxiw-2026-0037Keywords:
risk management, ED, Ishikawa diagram, spaghetti diagram, HFMEAAbstract
Aim. The aim of the study was to assess the feasibility of using the spaghetti diagram, the Ishikawa diagram and the HFMEA analysis to identify problems and risks, their causes, bottlenecks and waste in processes considered to be crucial by emergency department staff.
Material and methods. The research was carried out at the University Clinical Hospital in Opole. The following methods used included face-to-face interviews, observation of processes during gemba walks, the development of the spaghetti diagram,
the Ishikawa diagram and the use of healthcare failure mode and effect analysis (HFMEA).
Results. The study inculded two key processes: triage (according to15 nurses and 10 paramedics) and transferring of emergency department (ED) rooms between shifts (according to 10 nurses and 12 paramedics). The spaghetti diagram showed waste of staff time wasted on searching for a cell phone and going to the sink to moisten gauze pads needed for an electrocardiographic examination. The HFMEA analysis shows staff and equipment shortages, lack of management knowledge about problems occurring in the processes and a training deficit as potential causes of these problems.
Conclusions. The implementation of tools and solutions discussed in this paper is possible in emergency department and can provide errors risk reduction.
References
1. Font-Cabrera C, Juvé-Udina ME, Adamuz J, et al. Activity, triage levels and impact of the pandemic on hospital emergency departments: A multicentre cross-sectional Study. Emp. Res. Quant. 2025;81(3):1332-1342. https://doi: 10.1111/jan.16332
2. Goiana-da-Silva F, Costa S, Malcata F, et al. Addressing the overuse of hospital emergency departments in the Portuguese NHS: a new paradigm. Front. Publ. Health. 2025;12:1-8. https://doi:10.3389/fpubh.2024.1444951
3. Szlubowska A. Główny Urząd Statystyczny. Pomoc doraźna i ratownictwo medyczne w 2021r.; https://stat.gov.pl/obszarytematyczne/zdrowie/zdrowie/pomoc-dorazna-i-ratownictwo-medyczne-w-2021-roku,14,6.html
4. Savira F, Frith M, Aditya CJ, et al. Urgent care centres for reducing the demand on emergency departments: a scoping review of published quantitative and qualitative studies. Emergency Department Overcrowding: Understanding the Factors to Find Corresponding Solutions. Med. J. Aust. 2025;222(9):450-461. https://doi: 10.5694/mja2.52663
5. Chrusciel J, Fontaine X, Devillard A, et al. Impact of the implementation of a fast-track on emergency department length of stay and quality of care indicators in the Champagne-Ardenne region: a before-after study. BMJ Open. 2019;19(6):e026200. https://doi: 10.1136/bmjopen 2018-026200
6. Gedikli E. An evaluation of the wastes and obstacles within the context of lean management in emergency services. Health Sci. Q. 2025;5(1):87-97. https://doi.org/10.26900/hsq.2572
7. van den Berg M, van Loenen T, Westert GP. Accessible and continuous primary care may help reduce rates of emergency department use. An international survey in 34 countries. Fam.. Pract 2018;33(1):42-50. https://doi: 10.1093/fampra/cmv082
8. Pramusinta A, Jepisah D, Hasbi M. Ishikawa Diagram as a Tool for Resolving and Mapping the Causing Factors of Problems. Int. J. Adv. Multidisciplinary Res. Stud. 2025;5(2):600-603. https://doi.org/10.62225/2583049X.2025.5.2.3877
9. Złotowska K. Lean hospitals. Praktyczny przewodnik po Lean Healthcare. Jak optymalizować procesy w ochronie zdrowia tworząc wartość dodaną. Toruń: Wydawnictwo Lean Hospitals; 2020, s. 50-52.
10. Coelho Macedo JМ, Gestoso Á, Ramalho S, et al. The Implementation of HFMEA in a primary care emergency service of the portuguese national health system: A case study. Int. Healthcare Rev. 2025;18. https://doi.ora/10.56226/124
11. World Medical Association. (2024). Declaration of Helsinki – Ethical Principles for Medical Research Involving Human Subjects. 75th WMA General Assembly, Helsinki, Finland, October 2024
12. Locher D. Lean w biurze i usługach. Przewodnik po zasadach szczupłego zarządzania w środowisku pozaprodukcyjnym. Warszawa: Wydawnictwo MTBiznes; 2012, s.52.
13. Samimi A. Risk assessment in hospitals using the FMEA Method: A data-driven analysis for patient safety improvement. JAMPBR 2025;1:180-187. https://doi.org/10.22034/jampbr.2025.532120.1024
14. Najwyższa Izba Kontroli. Informacja o wynikach kontroli. Funkcjonowanie systemu ratownictwa medycznego. LWA.430.005.2020, nr ewid. 176/2020/P/19/105/LWA; Warszawa 2020. https://www.nik.gov.pl/plik/id,23528,vp,26262.pdf
15. Unwin M, Crisp E, Stankovich J, et al. Socioeconomic disadvantage as a driver of non-urgent emergency department presentations: a retrospective data analysis. PLoS ONE. 2020;15(4):e0231429. https://doi.org/10.1371/journal.pone.0231429
16. de Vries M, Fan M, Tscheng D, et al. Clinical observations and Healthcare Failure Mode and Effect Analysis to identify vulnerabilities in the security and accounting of medications in Ontario hospitals: a study protocol. BMJ Open. 2019;9:e027629. https://doi.org/10.1136/bmjopen-2018-027629
17. Dadashi T, Hosseinpoor S, Mohammadi A. A comprehensive protocol for evaluating health, safety, and environmental risks of hospital solid waste through FMEA technique. MethodsX. 2024;12:102760. https//doi.org/10.1016/j.mex.2024.102760
18. Jen-Shu C, Ching C, Shih-Ching L, et al. Healthcare failure mode and effect analysis combined service blueprint – Mitigating mass casualty triage in emergency units: A qualitative study. Int. Emerg. Nurs. 2024;77:1-9. https://doi.org/10.1016/j.ienj.2024.101508
19. Westbrook JI, Raban MZ, Walter SR, et al. Task errors by emergency physicians are associated with interruptions, multitasking, fatigue and working memory capacity: a prospective, direct observational study. BMJ Qual. Saf. 2018;27:655-663. http://dx.doi.org/10.1136/bmjqs-2017-007333
20. Moldovan F, Blaga P. Applying quality improvement approaches for the control of critical medical processes in a healthcare facility. Acta Marisiensis. SeriaTechnologica 2021;18(2):19-23. https://doi: 10.2478/amset-2021-0013
Downloads
Published
Issue
Section
License
Copyright (c) 2026 Authors
This work is licensed under a Creative Commons Attribution 4.0 International License.
